TRIUMPH IV

46 CFR 176.600(d) - Whenever damage or deterioration to hull plating or structural members that may affect the seaworthiness of a vessel is discovered or suspected, the cognizant OCMI may conduct an internal structural examination...and may require the vessel...to effect permanent repairs. Bottom shell in the steering space is fractured approximately 6" in length just port of centerline and just aft of the fuel tank propagating out of the fillet weld attachment of the transverse bracket. The bracket weld attachment to the inboard bottom longitudinal is also fractured. Provide repair proposal and conduct repairs to the satisfaction of the attending marine inspector.

Marine inspectors witnessed a deteriorated foam vapor barrier on the port side of the forward bulkhead of the machinery space in a electrical cable passage.

The visual indicator at the operating station for the high level alarm labeled as "Aft" and which served the lazarette and engine room spaces was found to be nonfunctional during inspection.

Vessel is required to haul out and be made available for post casualty inspection by a USCG Marine Inspector prior to carrying passengers.

CLSN: Vsl is broadcasting Invalid Call Sign (Numbers transposed)

Two nonmetallic flexible hoses chaffed through the outer layer on starboard engine directly under main Racor fuel filter.

Broken welds on transverse stiffener on both port and starboard sides, three longitudinals out from keel.

Make vessel available for inspection of propellers, rudders, shaft and hull as result of collision on Columbia River. Vessel may not be used in commerical service and is limited to no more than six passengers until the vessel has been examined and reparis made to the satisfaction of the attending marine inspector.

Port and starboard stern tubes showed signs of galvanic corrosion on the aft section in way of the cutlass bearing and needs to be repaired. - 46CFR182.200

REPLACE IN KIND THE STARBOARD PROPELLER TO THE SATISFACTION OF THE ATTENDING CG MARINE INSPECTOR PRIOR TO THE CARRIAGE OF PASSENGERS.

Install insulation on exhaust piping for both diesel engines to the satisfaction of the marine inspector IAW 46 CFR 177.10-5(b).

The E/R's fwd bulkhead was found to be not vaportight as required by 46 CFR 177.405(c).

Make vessel available for hull examination in order to assess any damage due to hull strike.

Provide 6 adult life jackets. Passengers carried are restricted to 9.

Provide updated charts, lightlist, currents, and Coast Pilot publications.

Renew both main engine oil gallery and fuel return hoses with hoses meeting the J-1942 standard.

Renew stbd main engine secondary fuel filter supply hose.

Seal ship's service generator exhaust pipe at aft bkhd.

Provide and install protective cover for engine compartment light.

REPLACE BOTH PROPELLERS DUE TO DAMAGE FROM LOG IMPACT.

Determine specific condition that is adversely affecting two cylinders on the port engine and make repairs to the satisfaction of a Coast Guard Marine Inspector, to include sea trials.

Repair leaking lube oil hose on port engine. 46 CFR 182.455 Complete to the satisfcation of a USCG Marine Inspector.

Upon completion of installation of marine reduction gears, conduct seatrials to the satisfaction of the attending USCG marine inspector, prior to the carriage of passengers. (Both drive gears were overhauled during drydock)

Prove operation of the aux genset to the satisfaction of the attending USCG marine inspector. (Genset was newly installed as in-kind electrically during drydock.)

Provide an audible bilge alarm at the operating station. Alarm must be loud enough to be heard by the operator through all speed ranges. 46 CFR 182.530(a)

Renew/Replace stbd engine RPM gauge. 46 CFR 182.410(b)

Repair weld on inboard transverse stiffener for skeg on stbd side where now separated from longitudinal. In way of lazarette.

Repair welds on starboard quarter at transom where it meets deck plate in way of lazarette.

Perform underway drills in presence of a Coast Guard Marine Inspector.

Renew 3 adult life jackets. Complete no later than 15Aug04. Passenger count reduced to 12 until this item is completed. 46CFR180.71

Mark the location of the child life jackets with appropriate label. Complete NLT 15Aug04. 46CFR180.78(a)(5).

Relocate the 2 B-II fire extinguishers to the outside of the engine space (currently mounted inside the engine space). Complete prior to carriage of passengers. 46CFR181.30-10(b) (Old T).

Renew valve handle for the port sea strainer (handle missing/broken off). 46CFR176.25-5(a)(2). Complete NLT 15Aug04.

Repair or renew Ring Buoy (Lifeline). This item must be completed prior to carriage of passengers. LEGACY COMPONENT DESC: Buoyant Lifeline

Restow buoyant lifeline to facilitate immediate deployment. This item must be completed prior to carriage of passengers. LEGACY COMPONENT DESC: Buoyant Lifeline

Renew battery for ring buoy water light. This item must be completed prior to carriage of passengers. LEGACY COMPONENT DESC: Self-igniting Lights

Renew glass where broken, forward starboard window on the house.

Provide valid FCC radio operator's permit.

Renew expired items in first aid kit. LEGACY COMPONENT DESC: Medicine Chest

Provide and post emergency instructions. LEGACY COMPONENT DESC: Emergency Instructions

Double clamp hose for bilge pump suction. LEGACY COMPONENT DESC: Hose

Repair and demonstrate operation of starboard main engine tachometer. LEGACY COMPONENT DESC: Gauges

Conduct Fire and Man Overboard drills in the presence of a Coast Guard inspector. LEGACY COMPONENT DESC: Fire

Demonstrate that the company's drug testing program complies with the requirements of 46 CFR part 16. LEGACY COMPONENT DESC: CG Notification (positive results/refusals)

Replace broken starboard side pilot house window with safety glass. LEGACY COMPONENT DESC: Window, Pilot House

Provide servicing reports for portable fire extinguishers prior to carriage of passengers. LEGACY COMPONENT DESC: Service

Provide valid certificate of documentation. LEGACY COMPONENT DESC: Certificate of Documentation (CG-1270)

Remove or properly install head/MSD. LEGACY COMPONENT DESC: Toilet

Conduct operational tests to satisfaction of attending marine inspector (MOB/FF/ Nav Equip/ Propulsion/ Gauges). LEGACY COMPONENT DESC: Man Overboard Recovery

Repair fractured internal welds at port & starboard corners where deck and transom connect. LEGACY COMPONENT DESC: Side Shell

Provide non-reative lining for both battery boxes._x001C_ _x001C_ _x001C_ _x001C_

Renew expired items in first aid kit.

Label side windows in forward passenger compartment as "EMERGENCY EXIT" IAW46CFR177.500 and 46CFR185.606

PROVIDE UPDATED CHARTS AND NAVIGATION PUBLICATIONS FOR OPERATING AREA.

INSTALL HIGH LEVEL BILGE ALARMS PER 46 CFR 184.404.

OBTAIN FCC SAFETY RADIOTELEPHONY CERTIFICATE. VESSEL IS TO REMAIN WITHIN 1000 FT OF SHORE UNTIL CORRECTED.

REPAIR/REPLACE STRAP ON ONE CHILD PFD.

VESSEL IS TO CONDUCT STABILITY TEST DUE TO THE CARRIAGE OF DECK CARGO.

PROVIDE MEANS TO CONDUCT PASSENGER COUNT.

REMOUNT WATERLIGHT FOR RING BUOY TO ALLOW FLOAT FREE OPERATION.

INSTALL 3 TO 6 FOOT LANYARD WITH DETACHABLE CLIP ON RING BUOY LIGHT.

PROVIDE AN UPDATED FIRST AID KIT IAW 46 CFR 160.041.

CONDUCT SATISFACTORY MAN OVERBOARD DRILL IN THE PRESENCE OF A MARINE INSPECTOR.

PROVIDE FCC MARINE RADIO OPERATOR'S PERMIT FOR VESSEL MASTER.

PROVIDE ON BOARD A VALID (FCC) RADIO TELEPHONY SAFETY CERTIFICATE.