SUNFISH

Light. The light must be a floating waterlight approved under approval series 161.010 or other standard specified by the Commandant. The floating waterlight must be attached around the body of the life float or buoyant apparatus by a 10 mm (3/8 inch) lanyard, resistant to deterioration from ultraviolet light, and at least 5.5 meters (18 feet) in length. Port aft life float light did not work when tested. Repair life float light to the satisfaction of the attending marine inspector.

Waste receptacles. Unless other means are provided to ensure that a potential waste receptacle fire would be limited to the receptacle, waste receptacles must be constructed of noncombustible materials with no openings in the sides or bottom. Vessel had combustible waste receptacles on board. Remove combustible waste receptacles and replace with metal or Sub chapter Q approved non combustible type.

Repairs or alterations to the hull, machinery, or equipment that affect the safety of the vessel must not be made without the approval of the cognizant OCMI, except during an emergency. During the dry dock examination the following items were found and need to corrected before issuance of dry dock credit. Forward keel showed delamination from the hull structure. Fasten delaminated section of forward keel to the hull. 46 CFR 176.700

Repairs or alterations to the hull, machinery, or equipment that affect the safety of the vessel must not be made without the approval of the cognizant OCMI, except during an emergency. During the dry dock examination the following items were found and need to corrected before issuance of dry dock credit. Approximately a 6"x6" section of exposed wood was found above starboard propeller. Remove any rot and fill. 46 CFR 176.700

An individual may not be engaged or employed, including self-employment, on a vessel in a position as master, operator, or person in charge for which a credential is required by law or regulation unless all crewmembers covered by this section are subject to the random testing requirements of this section. Vessel master was not listed on the consortium covered crew list. Provide documentation that master is subject to random testing for the company.

A vessel must comply with the applicable requirements for any radio and Electronic Position Indicating Radiobeacon (EPIRB) installations, including the requirements for a station license and installation certificates to be issued by the Federal Communications Commission, as set forth in 47 CFR part 80. The FCC Safety radio Telephony Certificate (installation certificate) was not available for inspection. Provide valid FCC safety radio telephony certificate.

A vessel must be provided with a satisfactory arrangement for draining any watertight compartment, other than small buoyancy compartments, under all practicable conditions. Vessel was unable to dewater the crash locker or the lazarette. Demonstrate the dewatering of all watertight compartments to the satisfaction of the attneding USCG marine inspector.

Each vessel must be equipped with a public address system which be must be audible during normal operating conditions throughout the accommodation spaces and all other spaces normally manned by crew members. Aft deck public address speaker not operable. Demonstrate public address system for all required spaces.

On a vessel on which the number of passengers permitted on upper decks is limited by stability criteria, as indicated by the vessel's stability letter, the maximum number of passengers allowed on an upper deck must be indicated by a durable marking of at least 25 millimeters (1 inch) numbers and letters at the entranceway to that deck. Passengers not permitted on upper deck, but no markings were present. Mark upper deck as restricted to crew only.

The Rules concerning shapes shall be complied with by day. The lights and shapes specified in these Rules shall comply with the provisions of Annex I of these Rules (33 CFR part 84). Vessel was not carrying day shapes. Provide day shapes.

The marine employer must have a sufficient number of alcohol testing devices readily accessible on board the vessel to determine the presence of alcohol in the system of each individual who was directly involved in the SMI. The alcohol testing devices need not be carried on board each vessel if obtaining the devices and conducting the required alcohol tests can be accomplished within 2 hours from the time of occurrence of the SMI. Alcohol testing devices not on board. Provide alcohol testing devices.

All cable and wire must be installed with metal supports spaced not more than 610 millimeters (24 inches) apart, and in such a manner as to avoid chafing and other damage. 8AWG cable running on deck stringer above the inboard side of the port engine found without metallic supports. Provide proper cable supports.

Except as allowed by paragraph (d) of this section, each vessel constructed of a material other than wood certificated to operate on a limited coastwise route in cold water must be provided with life floats of an aggregate capacity that will accommodate at least 100% of the total number of persons permitted on board. (c) Except as allowed by paragraph (e) of this section, each vessel certificated to operate on a limited coastwise route in warm water must be provided with life floats of an aggregate capacity that will accommodate at least 50% of the total number of persons permitted on board. Vessel;s life raft servicing is overdue. Vessel is prohibited from carrying passengers or cargo until it is provisioned with primary lifesaving meeting the type and capacity of 46 CFR 180.205.

Anchor light inoperable. Demonstrate proper operation of all navigation lights.

Vessel is required to have three 2.5 gallon fire buckets, but only has two. Provide additional fire bucket.

Vessel's genset was not properly grounded causing arching and sparking upon starting.

Provide FCC station License, Safety certificate, & Operator's permit.

Provide updated DAPI program including MIS report.

Provide current charts, coast pilot, light list and tides/currents.

Provide record of monthly EPIRB testing.

Provide hydrostatic release for EPIRB showing expiration date.

Provide serviceable ring life buoy.

Demonstrate proper operation of starboard main engine oil pressure gauge.

[withheld — contains personal information; the deficiency system, dates, and resolution status are shown above]

Provide FCC general marine operators permit.

Renew EPIRB battery or purchase a new one; restricted to 3NM from shore.

Renew hydrostatic release on EPIRB.

Re-register EPIRB with NOAA.

Update first aid kit.

Provide service report for IBA by 31MAY18.

Provide alcohol testing devices on board.

Mount 02 portable fire extinguishers in brackets.

Post current COI.

Complete annual servicing of 50-person IBA and replace expired hydro release prior to carrying passengers.

Complete an inspection for renewal of the Certificate of Inspection. Vessel may not carry passengers for hire until satisfactory completion of the inspection.

Provide 6 hand red flare distress signals & 6 hand orange smoke distress signals.

Renew EPIRB registration prior to operating beyond 3 NM.

Provide alco testers prior to operating more than 2 hrs from dock.

Make regular crew available for underway safety drills.

Provide (05) Type I lifejackets; vsl ltd to carriage of 47 total persons until cleared.

Provide current/valid FCC Radiotelephony Certificate.

Label E/R electrical panel circuit breakers.

Connect VHF-DSC to a GPS source and enter MMSI number.

Provide a current NOAA Chart 18725 for operating area.

Provide current copies of U.S. Coast Pilot & USCG Light List.

Post emergency broadcast placard at operating station.

Post EAP community service hotline number visible to crew.

Provide annual MIS report from Maritime Consortium.

Provide copies of employer policy regarding drug/alcohol use in workplace.

NLT 01APR16 provide proof of annual servicing of IBA.

Secure ladder in gen compartment

Provide proof of current FCC SSL

Renew expired contents of first aid kit

Label all PFD storage locations

Replace portable B-II extinguisher or hydro test bottle

Replace all non approved welding cable in the E/R.

Have Inflatable liferaft serviced

Replace 10 unserviceable Kapok Type I life jackets

replace steering ram support bracket fastners

Prove operation on Engine room vent closures

Post & provide, as required, EAP info required by 46 CFR 16.401

Prior to operating outside Ventura Harbor, provide alco testing devices.

Prior to ops outside Ventura Hbr, provide hydro release for life raft.

Prior to ops beyon 3NM, provide hydro release for EPIRB.

Provide anchor day shape

Close gap around shaft log in E/R-laz bulkhead.

Replace bilge hi-level audible alarm (works intermittently).

Repair or replace leaking generator raw water strainer.

Make forward escape hatch operable from both sides (open from inside and out).

Service/install life raft to the satisfaction of the attending marine inspector prior to operating with passengers.

Service fixed and portable fire extinguishers prior to operating with passengers.

Provide 22 adults and 6 children life jackets. Vessel is restricted to 30 adults and 0 children.

Secure refrigerator from shifting.

Provide CG light list &tide table.

Provide proof of chem testing enrollment.

Install & proof operation of anchor and mooring system to operating with pax.

Install & proof operational test of the radio.

Provide rigid dive flag.

Provide line diagram of the replaced electrical wiring, genset, and air compressor.

Lable e-escape from accom space prior to operating with pax.

Provide machinery guard to STBD main.

Install e-fuel shut off prior to operating with pax.

Secure loose wiring in the E/R with non combustible straps.

Label bilge manifold.

Label breaker box in the E/R.

Repair bonding wire in the E/R.

Install chafing gear via port engine raw water hose.

Complete installation of the E/R vent closure prior to pax.

Install aft access railing leading to the dive platform.

Seal aft comp ensuring water tight integrity.

Secure loose wiring IWO the lazarett.

Secure 12V bilge discharge hose IWO accom space.

Install red/white/red for restrictive maneuverability for night dive ops.

Secure loose wiring IWO pilot control station.

Install and proof operational test of the ship's horn prior to operating with pax.

Provide local navigation charts prior to operating with pax.

Clean accomodation of excess tools prior to carrying pax.

Provide additional smokes (3) and red flares (3) prior to pax.

Complete installation of the fix gas system.

Provide approved device to measure breath alcohol for 100% of the crew.

Complete simplified stability test upon completion of the modification.

Re-measured and document the vessel upon completion of modification.

Provide 2 flashlights for use as emergency lighting.

Provide means for securing ventilaiton to engine room through forward vents above port and stbd engine covers.

Renew ring buoy. Grab lines excessively deteriorated by U/V damage and can not be replaced w/o replacing ring buoy.

Repair forward mast head light.

Double hose clamp all pedro connections in bilge piping.

Repair broken window frame on port fwd side of vessel.

Conduct monthly EPIRB testing of 406 MHz EPIRB and properly document same.

Properly post emergency broadcast placard by VHF-FM radio in pilot house.

Post stability letter in pilot house.

Provide current FCC radio operators permit for vessel master.

Replace the STBD shaft in kind.

Update charts with local notices to mariners.

Renew secondary life buoy or remove from the vessel.

Renew outdated medication in first aid kit.

Repair minor blistering paint in way of port bow area and engine room.

Repair starboard aft rub rail.

Reset rudder bearing and adjust the steering linkage.

Tighten frame to bulkhead fasteners under the galley.

Make repair plan to address the water seepage under the keel cap.

Renew starboard hydraulic line from the engine room to the operator's station.

Reinforce steering rudder post bracket.

Renew life ring grab line.

Renew Masters FCC operators permit.

Conduct and log monthly EPIRB test.

Mark "Emergency Exit, Keep Clear" on the weather deck side of escape hatch.

Renew steering hydraulic line from the operator's station to the steering compartment.

Show proper operation of engine room high bilge alarm.

Show proper operation of main cabin high bilge alarm.

Replace broken glass at the operators station.

Show proper operation of fore peak bilge suction.

Provide portable battery light at the operating station and access to the engine room.

Secure stern post to deck beam to eliminate the steering foundation movement.

Provide current coast pilot.

Provide working lights for two lifejackets that didn't operate. LEGACY COMPONENT DESC: Lights

Renew retroreflective material on 5 lifejackets.

The vessel had a 20" lifebuoy located port side in conjunction with the required 24" lifebuoy located on the starboard side. Remove or replace the 20" lifebuoy with a 24" lifebuoy.

GROUND THE NEUTRAL WIRE AS REQUIRED BY 46 CFR 183.376.

SHOW PROOF THAT NO MORE THAN 30 AMPS CAN BE POWERED BY THE GENERATOR.

PROVIDE MEANS FOR EMERGENCY FUEL SHUT-OFF VALVE REMOTE ACTUATOR TO COMPLETELY CLOSE VALVE.

LABEL BILGE MANIFOLD IDENTIFYING SPACE SERVED.

RENEW LINES AS NECESSARY ON LIFEFLOATS THAT ARE DETERIORATED DUE TO U/V DAMAGE.

CLEAN OR RENEW LENSES FOR RUNNING LIGHTS. VESSEL IS RESTRICTED TO DAYLIGHTOPERATIONS ONLY UNTIL CORRECTED.

PROVE PROPER OPERATION OF MAST HEAD LIGHT. VESSEL IS RESTRICTED TO DAYLIGHT OPERATIONS ONLY UNTIL CORRECTED.

INSTALL CORROSION RESISTANT 30X30 MESH FLAME SCREEN ON FUEL TANK VENT.

PROVIDE VENT CLOSURE FOR STARBOARD AFT ENGINEROOM VENT OPENING. VESSEL IS RESTRICTED FROM CONDUCTING PASSENGER OPERATIONS UNTIL CORRECTED.

GROUND THE NEUTRAL WIRE AS REQUIRED BY 46 CFR 183.376.

GROUND ALL METALLIC AC ELECTRICAL ENCLOSURES AS REQUIRED BY 46 CFR 183.372.

SHOW PROOF THAT NO MORE THAN 30 AMPS CAN BE POWERED BY THE GENERATOR.

HAVE ON BOARD IN OPERATING CONDITION VOLT, AMP, AND FREQUENCY METER AS REQUIRED BY 46 CFR 183.320

CLAMP ALL AC WIRING EVERY 24" USING METALLIC STRAPS.

RENEW F/O HOSE ON GENERATOR USING APPROVED HOSE PER 46 CFR 182.720.

INSTALL AC SHORE RECEPTICLE IN AN APPROVED ENCLOSURE.

RENEW WIRE CLAMPS IN AC ENCLOSURES USING CORRECTLY SIZED CLAMPS.

REPLACE EXISTING SINGLE STRAND ELECRICAL WIRING USED FOR ELECTRICAL RECEPTACLES WITH APPROVED MARINE GRADE WIRING.

REPAIR AS NEW MAIN DECK AREA PORT AFT QUARTER BEHIND BENCH SEAT.

SERVICE FIXED FIRE EXTINGUISHING SYSTEM IN ENGINE ROOM.

PROVIDE NEW WEAK LINKS FOR THE PORT (11) PERSON AND TOPSIDE (6) PERSON LIFEFLOATS.

PROVIDE (4) ADULT AND (1) CHILD COAST GUARD APPROVED TYPE I LIFEJACKETS.

PROVIDE UPDATED FCC SAFETY RADIO CERTIFICATE.

LABEL LOCATION OF MANUAL PULL STATION FOR FIXED FIRE EXTINGUISHING SYSTEM.

REFASTEN AIR INTAKE SNORKELS FOR BOTH PROPULSION ENGINES.

RENEW THROW LINE AND WATERLIGHT LINE OF THE RING LIFEBUOY.

REPAIR AS NEW RING LIFEBUOY WATERLIGHT.

REPAIR AND PROVE PROPER OPERATION OF HIGH LEVEL BILGE ALARMS IN FOREPEAK, FORWARD ACCOMODATION BILGE, AND GALLEY BILGE.

Replace all PVC or plastic bilge piping and fittings in the engine room using approved metallic pipe. Non-ferrous pipe where used must have a melting temperature of less than 1700 degrees F or meet the specific requirements listed in 182.730.

Remove existing PVC pipe installed in bilge pumping system and replace withmettalic piping.

Provide Coast Guard approved or equivilant first aid kit.

Provide on Coast Guard approved type I PFD.

Repair anchor light.

Install bilge alarms in forepeak and in forward compartment below accomodation space in accordance with 46 CFR 166-199.

Repair wiring on starboard propulsion engine alternator.

Install flame guards on both propulsion engines racor fuel filters.

Install new weak link for port 11 man and topside 8 man lifefloats.

Provide current copy of T-Boat regulations 46 CFR 166-199.

Install halard clips on port and stbd side water light to ring buoy lines.

Replace tending lines on port and starboard ring buoys.

Replace steering system support beam.

Install flame screen on fuel tank vent.

Replace hinge support on forward emergency escape hatch.

Replace steering wheel support.

Repair damage to port and starboard aft quartar side hull around freeing ports.

Replace port and starboard cap railing from 3' back from bow to the transom.

Refasten loose port and stbd spray rails.

Provide a random sampling of fastners for inspection.

Provide 3 additional Coast Guard approved child lifejackets prior to carring more than 3 childern.

Provide 3 additional Coast Guard approved type 1 adult lifejackets prior tocarring more than 49 adults.

Reattach the E fuel shut off valve prior to carring passengers.

Provide a compass deviation table.

Get an up to date information from Consortium and file with drug testing program (USCG form CG-5573).

Replace Lifering prior to carring passengers.

Conduct Emergency drills, have a Coast Guard Marine Inspector witness.

PROVIDE LATEST STABILITY LETTER DATED 13JUN86.

PROVIDE VENTILATION FOR COMPARTMENT CONTAINING DIESEL TANK OF A SIZE NOT LESS THAN 1 AND 1/2" DIAMETER IN ACCORDANCE WITH 182.20-50(a)(1).

MAKE REPAIRS TO STBD RUNNING LIGHT. VESSEL IS RESTRICTED TO DAYLIGHT OPERATIONS ONLY UNTIL COMPLETED.

REPLACE FRESNEL LENS ON STERN RUNNING LIGHT.

CONDUCT FIRE AND RESCUE DRILLS IN THE PRESENCE OF A USCG MARINE INSPECTOR.

Properly support electrical wiring throughout vessel in accordance IEEE-45.

Repair/renew inner net and outer grabline of starboard upper deck_x001C_ lifefloat.

Conduct fire and rescue drill in the presence of the U. S. Coast Guard.

Make all life floats "float free".

Provide capture chain for lazerette hatch.

Renew EPIRB battery.

Provide rotating machinery guards for both main engines.

REPLACE 6 OUTDATED ORANGE SMOKE FLARES.

PROVIDE ONE ADDITIONAL B-II PORTABLE FIRE EXTINGUISHER PRIOR TO OPERATION OF THE VESSEL.

REPAIR LIFE LINES ON TWO 10-MAN LIFE FLOATS.

REPAIR ANCHOR LIGHT.

REPAIR AND PROVE PROPER OPERATION OF PORT MAIN ENGINE.

TIGHTEN UP SLOP IN STEERING CROSS BAR CONNECTION.

INSTALL ELECTRICAL BOND FROM FUEL TANK TO FILL.

BOLT EMPTY HOLE IN FOREPEAK BILGE SHUT OFF AT COLLISION BULKHEAD.

TIGHTEN STBD FUEL VALVE AND FITTINGS (LEAKING).

REFASTEN DECK CROSSBEAM AT STBD AFT CORNER OF ENGINE COMPARTMENT HATCH. SCRAPE AND TREAT ROT.

RENEW ALL GRAB LINES ON BOTH 11 MAN LIFEFLOATS AND REPLACE IMPROPER SIZE WEAK LINK WITH ONE RATED FOR 21 OR MORE PEOPLE PORT SIZE.

PROVIDE 12 ADDITIONAL PFD LIGHTS AND 9 ADULT LIFE JACKETS PRIOR TO CARRIAGE OF OVER 40 TOTAL PEOPLE ON OCEANS ROUTE OR 43 TOTAL PEOPLE ON LIMITED COASTWISE ROUTE.

REPAIR ABRAIDED FIBERGLASS ON 3 SMALL AREAS OF STBD 10 MAN LIFE FLOAT AND PROVIDE ONE ADDITIONAL 4 FOOT PADDLE.

REMOVE SURFACE ROT AT AREA BENEATH PORT SHAFT STRUT BACKING PLATE(IN LAZAR-ETTE) DRY AND COAT.

RECONNECT BROKEN GROUNDING STRAP AT STBD RUDDER.

REPLACE PORT PROPELLOR SHAFT AND STRUT BEARING.

MUCK OUT FOREPEAK TO FREE UP BILGE SUCTION.

PROVIDE COVER OVER ELECTRICAL TERMINALS STBD. SIDE OF PILOTHOUSE.

REPAIR LEAKS TO PORT AND STBD MAIN ENGINE RAW WATER EXHAUST.

PROVIDE DRAWINGS FOR ENGINEROOM INTAKE VENT MODIFICATION.

REPAIR OR RENEW HAND PUMP.

MODIFY 6" COAMING, PROVIDING GUIDES FOR INSTALLING.

PROVIDE (1) PADDLE FOR UPPER LIFE FLOAT AND RENEW CLEAT FOR GRAB LINE ON LOWER STBD LIFE FLOAT.

PAINT SIDE LIGHT SCREENS MATTE BLACK.

RENEW GLASS ON PORT SIDE OF DECKHOUSE.

MODIFY (2) UPPER LIFE FLOATS, SO THEY WILL FLOAT FREE.

ADD ADDITIONAL 780 SQUARE INCHES OF SCUPPER OPENINGS ON MAIN DECK.

REFASTEN OUTBOARD BULWARK SUPPORTS IN ENGINE ROOM, PORT AND STARBOARD.

SPLICE ALL LIFEFLOAT CONNECTING LINES.

PROVIDE 6" COMING FOR MAINDECK LOUNGE DOOR.

PROVIDE 3 ADULT LIFEJACKETS. TOTAL PERSONS ALLOWED IS REDUCED TO 46 UNTIL THIS REQUIREMENT IS COMPLETED.

PROVIDE NEW EPIRB BATTERY.

PROVIDE PILOTHOUSE OVERHEAD LIGHT COVER.