SAN JUAN-JAX BRIDGE

Freight Barge · Barge class · Built 1980s · USCG Southeast District (CGD-SE)

Built: 1984
Last inspected: 17 April 2026
Documentation: Valid · NVDC file of 10 August 2026
Inspections: 110
Deficiencies: 164 recorded · 0 without a recorded resolution
Controls: None recorded without a removal date
Inspected with: 11 other vessels

Coast Guard record current through 23 August 2026, retrieved 5 September 2026 from PSIX. Every field on this page was recorded by the Coast Guard. Records for the Barge class in Maury's sources begin in 1972.

Inspection record

Last inspected 17 April 2026

Recorded inspections110

…physical examinations70

…administrative events11

…with no type recorded29

Deficiencies 164 recorded · 0 without a recorded resolution

Operational controls None recorded without a removal date

Years with a record 40 calendar years (1985–2026)

Every line above is a count of records the US Coast Guard wrote, or a date it recorded. A blank resolution means none was recorded in this data; it does not establish that a deficiency is outstanding. Years with a record are calendar years in which a record exists, not years in service. What Maury does not do.

Identity

667317

—

—

244194

Flag

UNITED STATES

Maury page id

psix-244194

Documentation record

Registered dimensions (L × B × D)699.2 ft × 104.0 ft × 20.0 ft

Registered tonnagegross 12,078 / net 12,078

ITC dimensions (L × B × D)699.2 ft × 104.0 ft × 20.0 ft

ITC tonnagegross 35,086 / net 10,525

BuilderMARINE POWER & EQUIPMENT · SEATTLE, WA, UNITED STATES · built 1984

Hull materialSteel

PropulsionUNSPECIFIED

Hull shapeUNSPECIFIED

Hull configurationUNSPECIFIED

Hailing portnew york, NY

Endorsements, as the file codes themcw_un, reg

DocumentationValid · issued 16 December 2025 · expires 31 December 2026

Service, as the file records itFreight Barge

Hull formbarge (Maury's inference from propulsion, hull shape, material and length, rule hf-1; not a recorded fact)

Tonnage as PSIX records it35086 - Convention (Subpart B), Gross Ton
12078 - Regulatory (Subpart C or D), Gross Ton
10525 - Convention (Subpart B), Net Ton
12078 - Regulatory (Subpart C or D), Net Ton

Every line above is a field of the National Vessel Documentation Center's file as served by NOAA Fisheries, dated 10 August 2026, matched to this hull on its Official Number. Registered and ITC measurements are two systems and are never combined. One snapshot is held so far; documentation history begins with the next.

Professional

The full record for this vessel

Behind this panel: 110 inspections, each with its date, unit and type; 164 deficiencies with the resolution recorded against each; operational controls, none recorded without a removal date; 11 other vessels inspected with it; no other recorded names; the documentation record: dimensions, tonnage, builder, hailing port and endorsements. Every line is a record the Coast Guard wrote; the counts above are the same counts as in the summary, and they are free.

Professional is $39 a month or $299 a year, or $19.99 a month locked for life at the founding rate, for the first 200 subscribers. It unlocks every detail section on every vessel page, fleet watch tied to your account, and ownership records on request. Already a subscriber? Sign in.

Maury does not score, rate or grade vessels, at any price.

Vessel history report

Every record for this hull, in one document — $299

Every recorded inspection, 1972 to 2026, in one chronology · every deficiency, with system, dates and resolution · operational controls imposed and removed · every name this hull has been recorded under · the vessels it was inspected alongside, and when · how its record compares with hulls of similar age and size, as a fact about the population and never a judgement about this vessel.

Read one first, in full: a forty-year chronology · a hull that changed operators four times · the sparse case, shown as an example, not for sale.

This report is in development and is not for sale yet. There is no date, and nothing is charged. Leave an email and we will tell you when it exists, once.

Inspected as a tow unit · 11

The Coast Guard recorded this vessel and the following in the same inspection activity — normally a tug and the barges in its tow. A recreational or unclassed hull in the same activity is held and not published, so it does not appear here: these lists are a floor, not a complete manifest.

Inspection history · 110

17 April 2026 Type not recorded

No type recorded · Marine Safety Unit Port Canaveral · USCG Southeast District (CGD-SE) · Activity 8353317

24 March 2026 COI Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 8331093

6 February 2026 Type not recorded

No type recorded · Sector St Petersburg · USCG Southeast District (CGD-SE) · Activity 8309878

28 January 2026 Type not recorded

No type recorded · Sector San Juan · USCG Southeast District (CGD-SE) · Activity 8302771

9 June 2025 Annual Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 8155401

11 September 2024 Type not recorded

No type recorded · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 8001595

24 May 2024 Annual Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 8284789

16 September 2023 Type not recorded

No type recorded · Sector San Juan · USCG Southeast District (CGD-SE) · Activity 7792759

22 August 2023 Internal Structural Exam

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 7774097

9 June 2023 Damage Survey · Administrative Inspection

Physical examination · Sector San Juan · USCG Southeast District (CGD-SE) · Activity 7716701

8 June 2023 Type not recorded

No type recorded · Sector San Juan · USCG Southeast District (CGD-SE) · Activity 7714239

18 May 2023 Annual Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 7691541

5 April 2022 Annual Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 7424751

19 January 2021 COI Inspection · Internal Structural Exam · Hull Examination

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 7126867

13 January 2021 Drydock Extension

Administrative · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 7123839

24 March 2020 MARPOL Annex I Examination · Annual Inspection · MARPOL Annex VI Survey · MTSA Verification

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 6930980

28 May 2019 MTSA Verification · MARPOL Annex I Examination · MARPOL Annex VI Survey · Periodic Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 6696479

30 August 2018 Type not recorded

No type recorded · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 6527243

21 August 2018 Internal Structural Exam

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 6518054

17 April 2018 Annual Inspection · MARPOL Annex VI Survey · MTSA Verification · MARPOL Annex I Examination

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 6392761

6 March 2017 MTSA Verification · Deficiency Check · MARPOL Annex VI Survey · Administrative Inspection · Annual Inspection · MARPOL Annex I Examination

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 6099357

12 April 2016 Deficiency Check

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 5852729

1 February 2016 Drydock Exam · Administrative Inspection · MARPOL Annex VI Survey · MARPOL Annex I Examination · COI Inspection · Internal Structural Exam

Physical examination · Sector New Orleans · USCG Heartland District (CGD-H) · Activity 5807242

19 June 2015 Type not recorded

No type recorded · Sector San Juan · USCG Southeast District (CGD-SE) · Activity 5190197

16 April 2015 Annual Inspection · MARPOL Annex VI Survey · Deficiency Check · MARPOL Annex I Examination

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 5104882

26 March 2015 Damage Survey · Deficiency Check

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 5091210

18 March 2015 Damage Survey

Physical examination · Sector San Juan · USCG Southeast District (CGD-SE) · Activity 5086174

15 March 2015 Type not recorded

No type recorded · Sector San Juan · USCG Southeast District (CGD-SE) · Activity 5086974

24 June 2014 Type not recorded

No type recorded · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 4898795

1 May 2014 MARPOL Annex I Examination · Annual Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 4848194

23 March 2014 Type not recorded

No type recorded · Sector Miami · USCG Southeast District (CGD-SE) · Activity 4822625

5 September 2013 Internal Structural Exam

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 4684958

20 October 2012 Type not recorded

No type recorded · Sector Miami · USCG Southeast District (CGD-SE) · Activity 4469830

5 April 2012 MARPOL Annex I Examination · MTSA Verification · Annual Inspection · MARPOL Annex VI Survey

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 4279561

19 August 2011 Deficiency Check

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 4120268

11 August 2011 In-Service Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 4113285

28 July 2011 In-Service Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 4103249

30 November 2010 MARPOL Annex I Examination · COI Inspection · Internal Structural Exam · Drydock Exam · MARPOL Annex VI Survey

Physical examination · Sector New Orleans · USCG Heartland District (CGD-H) · Activity 3901316

1 September 2010 Type not recorded

No type recorded · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 3840378

13 May 2010 Deficiency Check · Annual Inspection · MARPOL Annex I Examination · MTSA Verification

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 3715144

18 January 2010 Administrative Inspection · Deficiency Check

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 3667172

1 January 2010 Damage Survey

Physical examination · Sector San Juan · USCG Southeast District (CGD-SE) · Activity 3657731

7 April 2009 MARPOL Annex I Examination · Annual Inspection · MTSA Verification

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 3448054

5 January 2009 Deficiency Check · Internal Structural Exam

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 3390288

11 June 2008 MARPOL Annex I Examination · MTSA Verification · Annual Inspection

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 3234037

12 October 2007 Deficiency Check

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 3078326

6 September 2007 Annual Inspection · MARPOL Annex I Examination · MTSA Verification

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 3037250

24 November 2006 Administrative Inspection · Deficiency Check

Physical examination · Sector New Orleans · USCG Heartland District (CGD-H) · Activity 2827648

7 September 2006 Deficiency Check

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 2772943

10 August 2006 Plan Review (Other than "T")

Administrative · Marine Safety Center (MSC) · Activity 2742738

5 June 2006 Hull Examination · Administrative Inspection · COI Inspection · Internal Structural Exam · Deficiency Check · MTSA Verification

Physical examination · Sector New Orleans · USCG Heartland District (CGD-H) · Activity 2670791

1 June 2006 Type not recorded

No type recorded · Sector San Juan · USCG Southeast District (CGD-SE) · Activity 2668282

6 April 2006 Damage Survey

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 2618463

21 March 2006 Security Plan Review - VSP

Administrative · Marine Safety Center (MSC) · Activity 2606628

12 January 2006 Internal Structural Exam

Physical examination · Sector Jacksonville · USCG Southeast District (CGD-SE) · Activity 2566029

19 May 2005 Annual Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 2366712

14 January 2005 Damage Survey

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 2274927

13 February 2004 Annual Inspection · Internal Structural Exam

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 2006446

28 January 2004 Administrative Inspection

Administrative · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1995147

15 January 2003 COI Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1730950

14 March 2002 Annual Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1493728

11 April 2001 Hull Examination

Physical examination · MSO TAMPA · USCG Southeast District (CGD-SE) · Activity 1451684

3 March 2001 COI Inspection · Deficiency Check

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1445747

30 January 2001 Administrative

Administrative · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1056557

4 January 2001 Type not recorded

No type recorded · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1466185

18 April 2000 Type not recorded

No type recorded · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1048692

23 March 2000 COI Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1384394

13 November 1999 Type not recorded

No type recorded · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 126309

12 November 1999 Administrative

Administrative · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 805942

15 September 1999 Type not recorded

No type recorded · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 72936

18 June 1999 Type not recorded

No type recorded · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 679887

17 June 1999 Re-Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1452521

28 January 1999 Hull Examination

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1397071

6 May 1998 Deficiency Check

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 790372

23 April 1998 COI Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 792241

3 June 1997 Re-Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 773659

13 January 1997 Administrative

Administrative · MSO NEW ORLEANS · USCG Heartland District (CGD-H) · Activity 1102457

31 December 1996 Administrative

Administrative · MSO NEW ORLEANS · USCG Heartland District (CGD-H) · Activity 1097112

4 June 1996 Deficiency Check

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 874814

9 May 1996 COI Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1083118

3 May 1996 Deficiency Check · Permit to Proceed · Hull Examination

Physical examination · MSO NEW ORLEANS · USCG Heartland District (CGD-H) · Activity 1419597

26 February 1996 Administrative

Administrative · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 884907

24 January 1996 Hull Examination

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 878994

7 February 1995 COI Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1148363

12 January 1995 Deficiency Check

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1173014

29 December 1994 Deficiency Check

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1160801

22 December 1994 Damage Survey

Physical examination · MSO SAN JUAN · USCG Southeast District (CGD-SE) · Activity 1457225

21 December 1994 Type not recorded

No type recorded · MSO SAN JUAN · USCG Southeast District (CGD-SE) · Activity 36094

26 July 1994 Deficiency Check

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 868018

3 May 1994 Deficiency Check

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1169271

13 April 1994 Type not recorded

No type recorded · MSO SAN JUAN · USCG Southeast District (CGD-SE) · Activity 65643

9 April 1994 Type not recorded

No type recorded · MSO SAN JUAN · USCG Southeast District (CGD-SE) · Activity 127895

9 February 1994 Re-Inspection · Hull Examination

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 853301

4 September 1993 Type not recorded

No type recorded · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 178678

11 February 1993 COI Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 834597

7 May 1992 Damage Survey

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1472837

26 February 1992 Deficiency Check

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 1425258

19 February 1992 Administrative

Administrative · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 944344

12 February 1992 Re-Inspection

Physical examination · MSO JACKSONVILLE · USCG Southeast District (CGD-SE) · Activity 956271

19 February 1991 Hull Examination · COI Inspection

Physical examination · MSO PUGET SOUND · USCG Northwest District (CGD-NW) · Activity 930370

3 July 1990 Type not recorded

No type recorded · MSO PUGET SOUND · USCG Northwest District (CGD-NW) · Activity 909374

7 September 1989 Type not recorded

No type recorded · Marine Safety Unit Valdez · USCG Arctic District (CGD-A) · Activity 887601

29 June 1989 Type not recorded

No type recorded · MSO PUGET SOUND · USCG Northwest District (CGD-NW) · Activity 1207544

24 December 1986 Administrative

Administrative · MSO PUGET SOUND · USCG Northwest District (CGD-NW) · Activity 1309001

9 May 1986 Deficiency Check

Physical examination · MSO PUGET SOUND · USCG Northwest District (CGD-NW) · Activity 1303804

11 April 1986 Type not recorded

No type recorded · MSO PUGET SOUND · USCG Northwest District (CGD-NW) · Activity 459031

10 April 1986 COI Inspection

Physical examination · MSO PUGET SOUND · USCG Northwest District (CGD-NW) · Activity 1307593

12 December 1985 Type not recorded

No type recorded · MSO ANCHORAGE · USCG Arctic District (CGD-A) · Activity 525038

30 July 1985 Type not recorded

No type recorded · MSO ANCHORAGE · USCG Arctic District (CGD-A) · Activity 455710

27 June 1985 Re-Inspection

Physical examination · MSO PUGET SOUND · USCG Northwest District (CGD-NW) · Activity 992195

Deficiency record · 164

02 - Structural Conditions › N/A - No Subsystem › Hull damage impairing seaworthiness

Issued 9 June 2023 Resolved

A survey, either general or partial, according to the circumstances, shall be made every time an accident occurs or a defect is discovered which affects the safety of the vessel or the efficacy or completeness of its lifesaving appliances, fire-fighting or other equipment, or whenever any important repairs or renewals are made. The survey shall be such as to insure that the necessary repairs or renewals have been effectively made, that the material and the workmanship of such repairs or renewals are in all respects satisfactory, and that the vessel complies in all respects with the regulations in this subchapter. Vessel was impacted in the aft port corner by towing vessel. Substantial damage has been identify.

Action required: 17 - Rectify deficiencies prior to departure
Resolved 20 July 2023
Resolution: CLASS Report used as objective evidence, def cleared.

Engineering › Fuel Oil Service System › Valve, Control

Issued 6 March 2017 Resolved

Repair the STBD GenSet remote fuel shut off valve reach rod. 46CFR56.50-75

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 10 May 2017
Resolved 9 May 2017
Resolution: A new stainless steel reach rod was installed on the STBD genset.

Electrical › Electric Generation Source (service) › Generator

Issued 7 March 2016 Resolved

rep could not demonstrate proper operation of P/S gen-set shut downs

Condition: Invalid
Action required: 705 - Other - as specified
Due 22 May 2016
Resolved 27 April 2016
Resolution: replaced units

Engineering › Compressed Air System (start air) › Valve

Issued 7 March 2016 Resolved

rep could not demonstrate proper operation of port side relief valve due to time constraints.

Condition: Invalid
Action required: 705 - Other - as specified
Due 22 April 2016
Resolved 12 April 2016

Electrical › Electric Generation Source (service) › Generator

Issued 7 March 2016 Resolved

stbd gen-set had a dead end wire that was previouly used as a sensor. one end was still connected to the gen-set. remove dead end wire.

Condition: Invalid
Action required: 705 - Other - as specified
Due 22 April 2016
Resolved 12 April 2016

Electrical › Lighting (service) › Outlet Box

Issued 7 March 2016 Resolved

found several junctions boxes through out bottom deck that had wires seperating from their junction box. Directed rep to survey area and make permanent attachements to junction boxes as they are found.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 22 April 2016
Resolved 12 April 2016

Construction/Loadline › Markings › Load Line Mark

Issued 16 April 2015 Resolved

The ring, lines and letters shall be painted white or yellow on a dark ground.

Action required: 705 - Other - as specified
Due 16 May 2015
Resolved 22 April 2015
Resolution: O/o painted port/starboard plimsol and deck lines

Accommodation/Occupational Safety › Occupational Safety › Portable Electric Equipment/Appliances

Issued 16 April 2015 Resolved

All 3 ballast control main disconnect and interlock (knive) switch are missing. #1 ballast controller supply power is by-passed, single phase conductor is spliced.

Action required: 705 - Other - as specified
Due 16 May 2015
Resolved 22 April 2015
Resolution: O/o installed approved disconnect/interlock switch in the aforementioned controllers.

Electrical › Electrical Distribution System (service) › Ground Detection

Issued 16 April 2015 Resolved

Ground detection system on main switchboard reflects an active ground on "c" phase. troubleshoot and isolate ground

Action required: 705 - Other - as specified
Due 23 April 2015
Resolved 17 April 2015
Resolution: O/o identified and isolated ground on lighting circuit.

Accommodation/Occupational Safety › Occupational Safety › Portable Electric Equipment/Appliances

Issued 16 April 2015 Resolved

Provide procedures to temporarily operate ballast pumps without the disconnect switch, such instructions shall be posted at the operating station, outside generator space and designated power panel.

Action required: 701 - Prior to carriage of passengers/cargo
Resolved 17 April 2015
Resolution: O/o submitted operating plan to MI outlining safety measures and procedures to operate ballast pump controllers.

Electrical › Electrical Distribution System (service) › Wiring

Issued 16 April 2015 Resolved

Remove excess twist-on connectors on ballast pump controllers.

Action required: 705 - Other - as specified
Due 23 April 2015
Resolved 22 April 2015
Resolution: O/o removed excess twist-on connectors on ballast pump controllers.

Construction/Loadline › Hull › Transverse Frame

Issued 18 March 2015 Resolved

Make temporary repairs IAW approved repair proposal to the satisfaction of the attending marine inspector

Action required: 705 - Other - as specified
Due 20 March 2015
Resolved 20 March 2015
Resolution: Witness fit up stbd side she''ll plate aprox 30x30 iwo fr 35 39. Main deck insert approx 5 x10 replace two frames approx 8 ft long. Replace tripping bracket and transverse long fr 36 37. Workmanship outstanding ABS surveyed repairs along wi

Construction/Loadline › Hull › Bracket

Issued 5 September 2013 Resolved

C/R #3 tripping bracket from bottom IWO Frame #10 outboard in Void 1S.

Due 1 February 2016
Resolved 12 April 2016

Construction/Loadline › Hull › Bracket

Issued 5 September 2013 Resolved

C/R #3 and #6 tripping bracket from bottom IWO Frame #10 outboard in void 2S.

Due 1 February 2016
Resolved 12 April 2016

Construction/Loadline › Hull › Bracket

Issued 5 September 2013 Resolved

C/R #4 and #6 tripping bracket from bottom IWO Frame #14 outboard in void 3S.

Due 1 February 2016
Resolved 12 April 2016

Construction/Loadline › Hull › Transverse Frame

Issued 5 September 2013 Resolved

Properly repair fractured weld on fwd #1 bottom tranverse floor frame where it connects to Stbd Bulkhead (Frame 7) in void 1C.

Due 1 February 2016
Resolved 12 April 2016

Construction/Loadline › Hull › Transverse Frame

Issued 5 September 2013 Resolved

Properly repair fracture on center-line bottom transverse floor frame where diagonal connects to frame; aft bulkhead (Frame 25/22) in void #5-5C.

Due 1 February 2016
Resolved 12 April 2016

Electrical › Electrical Distribution System (service) › Junction Box

Issued 5 April 2012 Resolved

Main deck: Properly mount electrical box, between frame 21-22, lane 10

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited J Box replacement

Electrical › Electrical Distribution System (service) › Wiring

Issued 5 April 2012 Resolved

Main deck: Properly reinstall wiring on light, frame 7. between lane 1-2

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited installed wires

Electrical › Lighting (emergency) › Lighting Fixture

Issued 5 April 2012 Resolved

Main deck: Properly replace light in exit sign in stbd eng room.

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited new signs

Construction/Loadline › Structures › Superstructure

Issued 5 April 2012 Resolved

Main deck: C/R stanchion, frame 8, between lane 3-5

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited insert on stanchion

Electrical › Electrical Distribution System (service) › Junction Box

Issued 5 April 2012 Resolved

Main deck: Main deck: Properly mount electrical box, between frame 21-22, outboard

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited J box replacement

Construction/Loadline › Structures › Superstructure

Issued 5 April 2012 Resolved

Main deck: C/R stanchion, frame 20, between lane 5-7

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited insert in stanchion

Construction/Loadline › Structures › Superstructure

Issued 5 April 2012 Resolved

Main deck: C/R stanchion, frame 16, between lane 5-7

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited insert in stanchion

Electrical › Lighting (service) › Lighting Fixture

Issued 5 April 2012 Resolved

Main deck: Properly mount light, frame 25, outboard

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited light monted properly

Electrical › Lighting (service) › Lighting Fixture

Issued 5 April 2012 Resolved

Main deck: Properly mount light, frame 32, between lane 5-7

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited monted light

Electrical › Lighting (service) › Lighting Fixture

Issued 5 April 2012 Resolved

Main deck: Properly mount light, frame 48, stbd

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited light

Construction/Loadline › Structures › Superstructure

Issued 5 April 2012 Resolved

Main deck: C/R bottom gusset, frame 40, between lane 1-3

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited insert of tripping bracket

Electrical › Electrical Distribution System (service) › Junction Box

Issued 5 April 2012 Resolved

Main deck: Properly mount electrical box, frame 50, stbd

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited electrical box in place

Accommodation/Occupational Safety › Occupational Safety › Deck Rail

Issued 5 April 2012 Resolved

3rd Deck: Properly repair rail, lane 10, port side

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited repaired rails

Accommodation/Occupational Safety › Occupational Safety › Guards for Exposed Hazards

Issued 5 April 2012 Resolved

Properly repair guard on stbd generator.

Due 5 May 2012
Resolved 3 May 2012
Resolution: Sited new guard on gen set

Electrical › Electrical Distribution System (service) › Ground Indicator

Issued 5 April 2012 Resolved

Prove proper operation of ground fault light in port eng room

Due 5 May 2012
Resolved 3 May 2012
Resolution: Ground fault repaired

Engineering › Diesel Engine (auxiliary) › Emergency shutdown

Issued 5 April 2012 Resolved

Show proper operation of eng shutdowns, port and stbd

Due 5 May 2012
Resolved 3 May 2012
Resolution: witness operation of engine shut downs

Engineering › Diesel Engine (auxiliary) › Block

Issued 13 May 2010 Resolved

Determine cause and repair Lube Oil leak, properly insulate exhaust lagging, and properly secure and seal fuel soleniod junction box.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 13 June 2010
Resolved 10 June 2010
Resolution: Lube oil leak was repaired, exhaust lagging was intalled and the fuel soleniod junction box was properly sealed.

Electrical › Lighting (service) › Conductor

Issued 13 May 2010 Resolved

Properly splice/connect wires located overhead of lanes 2 and 4; frame 41; 2nd deck.

Condition: Improper Installation
Action required: 705 - Other - as specified
Due 13 June 2010
Resolved 10 June 2010
Resolution: Overhead wires were properly connected.

Accommodation/Occupational Safety › Occupational Safety › Tripping/Falling Hazard

Issued 13 May 2010 Resolved

Re-Secure ladder to bulkhead on portside, main deck, at frame 25-13.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 13 June 2010
Resolved 10 June 2010
Resolution: Ladder was properly resecured to bulkhead

Electrical › Lighting (service) › Lighting Fixture

Issued 13 May 2010 Resolved

Submit plan for approval in regards to non-class 1 Div 2 flood lights installed throughout the vessel. Until such time as approved drawings are provided, lighting system is to be secured when Hazmat is being loaded, unloaded, or on board the vessel.

Condition: Placed in Improper Service
Action required: 705 - Other - as specified
Due 12 August 2011
Resolved 19 August 2011
Resolution: ABS APPROVED ELECTRICAL INSTALLATION.

Electrical › Electrical Distribution System (service) › Distribution Panel Bus

Issued 13 May 2010 Resolved

Renew or properly repair watertight covers on main deck stbd side ramp controller and control box for ballast valves.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 13 June 2010
Resolved 10 June 2010
Resolution: Watertight covers on ramp controllers and control box for ballast valves were repaired.

Accommodation/Occupational Safety › Occupational Safety › Receptacle Outlet

Issued 13 May 2010 Resolved

Replace latch on front panel of the hydraulic tank unit controller.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 13 June 2010
Resolved 10 June 2010
Resolution: Latch on the front panel of the hydraulic tank unit controller was replaced.

Electrical › Electric Supply System (service) › Cable

Issued 13 May 2010 Resolved

Replace wire tie cable supports w/ metal straps in stbd generator room on inboard bulkhead.

Condition: Improper Installation
Action required: 705 - Other - as specified
Due 13 June 2010
Resolved 10 June 2010
Resolution: Wire tie cable supports were replaced w/ metal straps.

Engineering › Freshwater System (air cooling) › Hose

Issued 13 May 2010 Resolved

Renew (2) identified jacket water flexible hoses and properly secure dead end wire on stbd generator.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 13 June 2010
Resolved 10 June 2010
Resolution: Two jacket water flexible hoses were renewed and dead end wires secured on stbd generator.

Deck/Cargo › Cargo Stowage › General

Issued 1 January 2010 Resolved

Barge is allowed a 1-time transit from San Juan to Jacksonville to conduct permanent repairs to deck&locking mechanisms (pull mans) on main 7&9/spot 11/deck 3. Rough weather caused containers to detach from deck&lean against safety rail. Additionally observed a 1in fracture on lane 8/spot 11/deck 3. No containers shall be carried on areas of concern and permanent repairs shall be made to class&cg.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 1 January 2010
Resolved 21 January 2010
Resolution: Repairs completed and ABS verified.

Accommodation/Occupational Safety › Occupational Safety › Deck Rail

Issued 16 April 2009 Resolved

Safety railing for ladder on the second deck car deck port side is missing. Install railing or remove car deck.

Condition: Improper Installation
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: railing installed.

Accommodation/Occupational Safety › Occupational Safety › Guards for Exposed Hazards

Issued 16 April 2009 Resolved

Protective heat guard is missing around the exhaust pipe at 2nd deck; car deck on port side. Install protective guard or remove car deck.

Condition: Design Flaw
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Protective lagging installed.

Accommodation/Occupational Safety › Occupational Safety › Rubbish/Waste Materials

Issued 16 April 2009 Resolved

Remove all remnants of pre-existing port side generator, including fuel lines, oil lines, filters, radiators, electrical wiring, brackets, and all oil residue.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Generator parts and permanent systems are being modified to allow for future re-install if desired.

Engineering › Diesel Engine (propulsion/auxiliary-electric) › Block

Issued 16 April 2009 Resolved

Entire area surrounding the portside generator is covered with oil. Clean up oil from engine and surrounding area.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Leak was discovered in seal. Seal is being replaced.

Engineering › Diesel Engine (propulsion/auxiliary-electric) › Overspeed Device

Issued 16 April 2009 Resolved

Overspeed trip failed to engage/shutdown. Overspeed trip must operate correctly prior to sail.

Condition: Improper/Lack of Maintenance
Action required: 701 - Prior to carriage of passengers/cargo
Resolved 17 April 2009
Resolution: Replaced overspeed component and properly demonstrated operation

Accommodation/Occupational Safety › Occupational Safety › Guards for Exposed Hazards

Issued 16 April 2009 Resolved

Stbd side service air compressor missing belt guard.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Belt guard installed.

Engineering › Fuel Oil Storage/Transfer System › Valve

Issued 16 April 2009 Resolved

Port and stbd fuel service tank remote valves not marked.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Remote valves marked.

Operations/Management › Pollution › Control of Discharge of Oil

Issued 16 April 2009 Resolved

Fuel containment burm at fueling deck riser/manifold missing plug.

Condition: Unknown
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Plug installed.

Accommodation/Occupational Safety › Occupational Safety › Tripping/Falling Hazard

Issued 16 April 2009 Resolved

Main Deck fwd compartment inboard of generator room; Ladder is missing lower bracket; bracket was removed during previous work item and not re-installed. Replace bracket or remove ladder. Light switch cable is wrapped around ladder; remove and re-install switch housing to bulkhead Lighting on port and stbd side of compartment broken.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Ladders removed, wiring secured, and swtich housing reinstalled.

Electrical › Lighting (service) › Outlet Box

Issued 16 April 2009 Resolved

Renew bracket for electrical box on 1st deck, frame 49, port side

Condition: Unknown
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Bracket renewed.

Electrical › Lighting (service) › Lighting Fixture

Issued 16 April 2009 Resolved

Repair cover for lighting panel L3 on the 1st deck and the handle for the ramp panel on the second deck

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Cover repaired.

Accommodation/Occupational Safety › Occupational Safety › Deck Rail

Issued 16 April 2009 Resolved

Repair stanchion at frame 32 and 38 in lane 7/5

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Stanchion repaired.

Accommodation/Occupational Safety › Occupational Safety › Deck Rail

Issued 16 April 2009 Resolved

Repair Handrail; 3rd deck, stbd side, 4th handrail from the bow

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Handrail repaired.

Electrical › Lighting (service) › Lighting Fixture

Issued 16 April 2009 Resolved

Repair or replace lights at frame 17 in lanes 6/4 and 1/2

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 16 May 2009
Resolved 14 May 2009
Resolution: Lighting replaced.

Electrical › Lighting (service) › Lighting Fixture

Issued 7 April 2009 Resolved

Repair/renew broken light fixture and bent bracket on lane 6-8, frame 38. Appears to have been hit by truck.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 29 May 2009
Resolved 29 May 2009
Resolution: Bracket was renewed and light fixture replaced and working properly.

Engineering › Diesel Engine (propulsion-electric) › Crankcase

Issued 7 April 2009 Resolved

Repair/renew seal on new port side generator and clean generator and surrounding areas of oil and residue. Seal is leaking.

Action required: 705 - Other - as specified
Due 29 May 2009
Resolved 29 May 2009
Resolution: Seal was renewed and is no longer leaking. Surrounding area was cleaned of all residue.

Engineering › Diesel Engine (propulsion-electric) › Block

Issued 7 April 2009 Resolved

The following is to be completed on the old port side generator: - REMOVE hot start system, raycor fuel filter system, and capillary pressure lines. - CAP OFF fuel lines and oil lines. - CONTAIN all electrical wiring in secure box. - LOCK OUT primary fuel filter valves. - CLEAN existing radiator of all oil and residue and surrounding areas.

Action required: 705 - Other - as specified
Due 29 May 2009
Resolved 29 May 2009
Resolution: All components of the old generator have been removed, contained, or locked out. The surrounding area has been cleaned of all oil and residue.

Construction/Loadline › Penetrations › Gasket

Issued 5 January 2009 Resolved

Properly secure the electrical cable penetration in the port fwd rake.

Condition: Placed in Improper Service
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 9 February 2009
Resolution: Cable penetration sealed.

Construction/Loadline › Hull › Longitudinal Frame

Issued 5 January 2009 Resolved

Crop and renew three tripped frames (5, 6, 8) in the center fwd rake, stbd side. At next dry-dock.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 5 August 2011
Resolved 9 February 2009
Resolution: Frames replaced.

Construction/Loadline › Hull › Hull Plating

Issued 5 January 2009 Resolved

Crop and renew the inset plate approximately 8ft X 12ft stbd side IWO the tripped frames in the center fwd rake. At next dry-dock.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 5 August 2011
Resolved 1 February 2011
Resolution: Completed repair satisfactorily examined and pressure box tested by USCG and ABS Veracruz

Construction/Loadline › Hull › Transverse Frame

Issued 5 January 2009 Resolved

In void 5-4 center port, on the port side repair the 3rd transverse frame forward bottom.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 9 February 2009
Resolution: Frames repaired.

Construction/Loadline › Hull › Keel

Issued 5 January 2009 Resolved

In void 5-4 center, on center line forward CVK check for cracks as marked.

Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 9 February 2009
Resolution: Some cracks found and repaired.

Construction/Loadline › Hull › Transverse Frame

Issued 5 January 2009 Resolved

In void 5-4 center, on the stbd side the #2 bottom transverse frame. Repair the fracture.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: Fracture repaired.

Construction/Loadline › Hull › Longitudinal Frame

Issued 5 January 2009 Resolved

In void 3 stbd, re-weld the #12 frame as needed.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: Frame is welded.

Construction/Loadline › Hull › Stiffener

Issued 5 January 2009 Resolved

In void 3 center, re-weld the top of frame 11.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 10 February 2009
Resolved 6 February 2009
Resolution: Frame repaired

Construction/Loadline › Hull › Stiffener

Issued 5 January 2009 Resolved

In void center, checkthe top of three diagonals as marked, for cracks.

Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: No cracks found

Fire Fighting › Means of Escape › Stairways

Issued 5 January 2009 Resolved

In void #3 center, repair the stbd ladder.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: Ladder repaired

Construction/Loadline › Structures › Manhole

Issued 5 January 2009 Resolved

In void 1 port, replace one stud on cover.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: Stud replaced

Construction/Loadline › Hull › Transverse Frame

Issued 5 January 2009 Resolved

In void 1 port, repair the fractured weld on frame #7 IWO the in board bulkhead.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: fracture repaired.

Construction/Loadline › Hull › Transverse Frame

Issued 5 January 2009 Resolved

In void #1 port, on frame #7 repair the fracture IWO the hull, 5ft from the top.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: Repairs were made

Construction/Loadline › Hull › Transverse Frame

Issued 5 January 2009 Resolved

In void #4 stbd, repair the fracture in the weld on frame 16 IWO the hull.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: Repairs were made

Construction/Loadline › Hull › Longitudinal Frame

Issued 5 January 2009 Resolved

In void #4 port, between frames 15 and 16, re-weld the frame the fourth frame from the bottom.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: Frames welded

Fire Fighting › Means of Escape › Stairways

Issued 5 January 2009 Resolved

In void 5-6 center, repair the 3rd step from the bottom of the ladder.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 9 February 2009
Resolved 6 February 2009
Resolution: Ladder repaired

Electrical › Electrical Distribution System (service) › Switch

Issued 6 September 2007 Resolved

Repair or replace the shut off switches and the covers on the ballast pump electrical panel 1&2

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: The switches were replaced.

Construction/Loadline › Structures › Superstructure

Issued 6 September 2007 Resolved

Repair or replace the support stanchion at frame 15 on the 1st deck, stbd side.

Condition: Unknown
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: The stanchion was replaced.

Electrical › Lighting (service) › Outlet Box

Issued 6 September 2007 Resolved

Install covers over missing breakers in panel L1, repair the lock on Panel L3

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: The covert was installed and the lock was repaired.

Electrical › Electric Generation Source (service) › Generator Cable

Issued 6 September 2007 Resolved

Remove all dead end wires, in the stbd generator room and on the #3 generator.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: Dead end wires are removed

Electrical › Electric Generation Source (service) › Panelboard

Issued 6 September 2007 Resolved

On #3 generator, secure the electric panel.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: Panel is secured

Deck/Cargo › Holds/Tanks › Scuttle

Issued 6 September 2007 Resolved

Make scuttles operational.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 11 August 2011
Resolved 12 June 2008

Engineering › Compressed Air System (start air) › Compressor

Issued 6 September 2007 Resolved

Port air compressor, investigate oil leak. Repair as needed.

Condition: Unknown
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: The leck was repaired

Pollution Prevention/Response › Prevention Equipment › Fixed Containment

Issued 6 September 2007 Resolved

Remove all oil and debris from containment area.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: The containment area is clean

Fire Fighting › Means of Escape › Stairways

Issued 6 September 2007 Resolved

Ensure all safety chains are placed around all ladders.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: Chains are up.

Construction/Loadline › Structures › Door

Issued 6 September 2007 Resolved

On the port side ramp electrical panel cover at frame 49, 2nd deck. Repair the hinge

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: The hinge was repaired.

Electrical › Electrical Distribution System (service) › Wiring

Issued 6 September 2007 Resolved

Between frames 27 and 28 on the 2nd deck. Repair or replace the wire or make connection inside a junction box.

Condition: Improper/Lack of Maintenance
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: New wire was installed.

Fire Fighting › Means of Escape › Handrails/Handholds

Issued 6 September 2007 Resolved

Repair the rail on the 3rd deck, stbd side at frame #5. Add strength members to the hand rail on the cat walk.

Condition: Unknown
Action required: 705 - Other - as specified
Due 6 October 2007
Resolved 4 October 2007
Resolution: More brackets were added

Engineering › Diesel Engine (auxiliary) › Overspeed Device

Issued 6 September 2007 Resolved

Demonstrate proper operation of the over speed shut downs on diesel engines.

Action required: 17 - Rectify deficiencies prior to departure
Resolved 7 September 2007
Resolution: Over speed devices were repaired and are working fine.

Construction/Loadline › Structures › Rake

Issued 5 August 2006 Resolved

Ramps originally installed in bottom lanes 3/5, 4/6, and 7/9 are condemned. Prove replacement as per approved drawings, prior to loading cargo.

Action required: 701 - Prior to carriage of passengers/cargo
Due 5 September 2006
Resolved 7 September 2006
Resolution: Ramps renewed or repaired satisfactory.

Construction/Loadline › Structures › Rake

Issued 5 August 2006 Resolved

Ramp originally installed on top deck 7/9 lanes has deep pitting. Initial guagings show up to 50% loss of metal. Mechanically clean and guage all pitted areas and submit repair proposal to local [name withheld] approved repairs OR replace deck in kind prior to loading cargo.

Action required: 705 - Other - as specified
Due 5 December 2006
Resolved 29 November 2006
Resolution: Received an approval letter for the proposed ramp inserts from CG MSC, examined ramp repairs, Ramps were repaired as per approved drawings.

Electrical › Lighting (service) › Lighting Fixture

Issued 5 August 2006 Resolved

Prove light globes and protective cages on all lane and bulkhead lighting.

Due 5 October 2006
Resolved 21 November 2006
Resolution: Installed new light covers throughout the vessel.

Accommodation/Occupational Safety › Occupational Safety › Deck Rail

Issued 5 August 2006 Resolved

Prove railing spacing on top deck complies with 46 CFR 92.25-5.

Due 5 December 2006
Resolved 22 November 2006

Construction/Loadline › Structures › Rake

Issued 5 August 2006 Resolved

Prove approval by Marine Safety Center concerning ramp design changes made while reconstructing ramps.

Due 5 September 2006
Resolved 10 August 2006

Construction/Loadline › Hull › Bottom Plating

Issued 5 August 2006 Resolved

Provide complete guaging and shipyard repair report.

Action required: 705 - Other - as specified
Due 5 March 2007
Resolved 11 September 2007
Resolution: Received gauging report and shipyard report.

Electrical › Electric Supply System (service) › Cable

Issued 5 August 2006 Resolved

Cover open junction box on main deck starboard side between frames 26-27.

Due 25 August 2006
Resolved 7 September 2006
Resolution: New junction box installed.

Electrical › Electric Supply System (service) › Cable

Issued 5 August 2006 Resolved

Mount electrical plug on mid level starboard side between frames 39-40.

Due 25 August 2006
Resolved 7 September 2006
Resolution: New electric box and plug installed.

Electrical › Lighting (service) › Lighting Branch Circuit

Issued 5 August 2006 Resolved

Cover lane lighting junction boxes (2) on mid deck lane 7/9...two lights closest to the ramps.

Due 5 October 2006
Resolved 5 October 2006
Resolution: Boxes were removed and cable run was shortened, and terminated at the next junction box.

Electrical › Lighting (service) › Lighting Fixture

Issued 5 August 2006 Resolved

Cover flourescent light on mid deck lane 1/2 just forward of aft windows between frames 30-31.

Due 5 October 2006
Resolved 5 October 2006
Resolution: Light cover was renewed.

Electrical › Electric Supply System (service) › Cable

Issued 5 August 2006 Resolved

Ensure all wiring is properly mounted and terminates in a junction box or light.

Due 5 November 2006
Resolved 29 November 2006
Resolution: Examined all wiring throughout the vessel and found satisfactory.

Construction/Loadline › Hull › Side Shell

Issued 6 April 2006 Resolved

Make permanent repairs by inserting the hull IWO damaged plating at approx frame 48, starboard side aft. Temp repairs authorized for transit to ship yard.

Condition: Damaged By Earlier Event
Action required: 705 - Other - as specified
Due 6 May 2006
Resolved 28 June 2006

Construction/Loadline › Hull › Weld

Issued 12 January 2006 Resolved

Complete work list repair items issued 1/12/06.

Condition: Unknown
Due 12 April 2006
Resolved 28 June 2006

Construction/Loadline › Hull › Hull Plating

Issued 14 January 2005 Resolved

PROVIDE CLASS REPORT ON DAMAGE IWO #3 PORT SIDE FRAME 15 AND 16 SIDE SHELL RIPPED APROX. 8 INCHES IN 4 SIDE SHELL LONG. K BRACKET ARE IN NEED OF REPLACING.

Condition: Unknown
Action required: 705 - Other - as specified
Due 15 February 2005
Resolved 15 January 2005
Resolution: RCVD CONDITION OF CLASS

Construction/Loadline › Structures › Deck Plating

Issued 14 January 2005 Resolved

PRIOR TO DEPARTATURE LOCATE AND REPAIR HOLE IN FRAME 16 AROUND CUT-OUT MAIN DECK WINDOW. LOCATE AND REPAIR HOLE IN MAIN DECK AROUND FRAMES AT WATER TIGHT BULKHEAD IN SPACE TOP COVER

Condition: Unknown
Action required: 705 - Other - as specified
Due 14 January 2005
Resolved 15 January 2005
Resolution: ABS CLEARED REPAIR

Construction/Loadline › Hull › Hull Plating

Issued 14 January 2005 Resolved

Vessel has an Condition of Class (ABS) IT IS RECOMMENDED THAT distorted port side shell and side shell longitudinal in way of frames 15 & 16 be cropped and renewed. Port side shell, 1st strake below main deck, set in over an area 9 x 8 to depth of 6".

Action required: 705 - Other - as specified
Due 15 March 2006
Resolved 28 June 2006

Engineering › Compressed Air System (start air)

Issued 13 February 2004 Resolved

Demonstrate proper operation of starboard air receiver relief valve. LEGACY COMPONENT DESC: Receiver/Bottle

Condition: Unknown
Action required: 705 - Other - as specified
Due 22 May 2004
Resolved 23 April 2004

Construction/Loadline

Issued 4 January 2001 Resolved

FRAME 33 CENTER VOID, REPAIR FRACTURE DIAGONAL SUPPORT ON BOTTOM AND PORT DECK STIFFNER BOTTOM GUSSET. FRAME 31 REPAIR FRACTURE IN IN STARBOARD FRACTURE._x001C_ _x001C_

Condition: Unknown
Due 4 January 2001
Resolved 4 January 2001

Construction/Loadline

Issued 4 January 2001 Resolved

VOID 5-3 PORT, FRAME 25-18, C/R #6 BRACKETAT SIDE SHELL, INSERT BULKHEAD ATSIDE SHELL BETWEEN LONGS 6 & 7._x001C_ _x001C_ _x001C_

Condition: Unknown
Due 4 January 2001
Resolved 4 January 2001

Construction/Loadline

Issued 4 January 2001 Resolved

FRAME 33, CENTER VOID, REPAIR FRACTURE ON DIAG SUPPORT._x001C_

Condition: Unknown
Due 4 January 2001
Resolved 4 January 2001

Construction/Loadline

Issued 4 January 2001 Resolved

FRAME 33, CENTER VOID, REPAIR FRACTURE ON PORT DECK STIFFNER BOTTOM GUSSET.

Condition: Unknown
Due 4 January 2001
Resolved 4 January 2001

Construction/Loadline

Issued 4 January 2001 Resolved

FRAME 25-18 CENTER VOID, REPAIR FRACTURE AT CVK DIAGONAL SUPPORT, FRAME 25-13 REPAIR FRACTURE CVK DIAGONAL._x001C_ _x001C_ _x001C_

Condition: Unknown
Due 4 January 2001
Resolved 4 January 2001

Construction/Loadline

Issued 4 January 2001 Resolved

FRAME 31 CENTER VOID, REPAIR FRACTURE ON STARBOARD BULKHEAD.

Condition: Unknown
Due 4 January 2001
Resolved 4 January 2001

Construction/Loadline

Issued 4 January 2001 Resolved

FRAME 24 CENTER VOID, REPAIR FRACTURE STARBOARD BULKHEAD, WELD TO BE TESTEDUPON REPAIR.

Condition: Unknown
Due 4 January 2001
Resolved 4 January 2001

Construction/Loadline

Issued 4 January 2001 Resolved

VOID 5-6 PORT, C/R BRACKET #5 AT SIDE SHELL BAY 1._x001C_ _x001C_ _x001C_ _x001C_

Condition: Unknown
Due 4 January 2001
Resolved 4 January 2001

Construction/Loadline

Issued 4 January 2001 Resolved

VOID 9 PORT, FRAME 42, C/R BRACKETS 1 & 2 AT SIDE SHELL, C/R # 1 LONG AT BULKHEAD._x001C_ _x001C_ _x001C_

Condition: Unknown
Due 4 January 2001
Resolved 4 January 2001

Documentation

Issued 17 June 1999 Resolved

Provide a valid IOPP certificate for vessel.

Condition: Unknown
Due 17 June 1999
Resolved 18 June 1999

Electrical

Issued 23 April 1998 Resolved

The #3 SSG was out of service. Required to repair and conduct load test and test of all emergency shutdown systems in presence of Marine Inspector.

Condition: Unknown
Due 23 April 1998
Resolved 23 April 1998

Engineering

Issued 23 April 1998 Resolved

Due to time constraints, a test of the pressure reliev valves on the air start compressors was not conducted. Required vessel to conduct test of the relief valves in the presence of a Marine Inspector.

Condition: Unknown
Due 23 April 1998
Resolved 23 April 1998

Electrical

Issued 23 April 1998 Resolved

The low l/o and high jacket water temp shutdowns on the #2 SSG were inoperative. Required to repair and conduct test in presence of Marine Inspector.

Condition: Unknown
Due 23 April 1998
Resolved 23 April 1998

Electrical

Issued 9 May 1996 Resolved

Demonstrate #1 generator under load, prove low lube oil trip, high jacket water temp trip, overspeed trip.

Condition: Unknown
Due 9 May 1996
Resolved 9 May 1996

Engineering

Issued 9 May 1996 Resolved

Demonstrate #2 generator low lube oil trip, high jacket water temp trip, overspeed trip.

Condition: Unknown
Due 9 May 1996
Resolved 9 May 1996

Electrical

Issued 9 May 1996 Resolved

Demonstrate #3 generator under load.

Condition: Unknown
Due 9 May 1996
Resolved 9 May 1996

Accommodation/Occupational Safety

Issued 9 May 1996 Resolved

Prove pressure relief valve on air receiver in stbd engine room.

Condition: Unknown
Due 9 May 1996
Resolved 9 May 1996

Construction/Loadline